North American LX 570 Fuel Tank capacity
#1
Driver School Candidate
Thread Starter
Join Date: Mar 2017
Location: BC
Posts: 4
Likes: 0
Received 0 Likes
on
0 Posts
North American LX 570 Fuel Tank capacity
Hello Guys, New to the forum
I checked with my friend who owns the same year LX 570 in China, the fuel tank capacity is 36.4Gallon(138L) but my Canadian LX 570 manual says I have 93L(25Gallon). Obviously, the difference between two version's gas tank capacity is not small, So I wonder is there any method to increase the fuel tanks' capacity in order to increase range.
I checked with my friend who owns the same year LX 570 in China, the fuel tank capacity is 36.4Gallon(138L) but my Canadian LX 570 manual says I have 93L(25Gallon). Obviously, the difference between two version's gas tank capacity is not small, So I wonder is there any method to increase the fuel tanks' capacity in order to increase range.
#2
Other parts of the world have a dual tank version. The standard 93 liter tank is supplemented by an additional 45 liter sub-tank mounted above the spare wheel. I'm interested in adding this sub-tank or an aftermarket alternative but don't have enough details to move forward.
#3
Driver School Candidate
Thread Starter
Join Date: Mar 2017
Location: BC
Posts: 4
Likes: 0
Received 0 Likes
on
0 Posts
Other parts of the world have a dual tank version. The standard 93 liter tank is supplemented by an additional 45 liter sub-tank mounted above the spare wheel. I'm interested in adding this sub-tank or an aftermarket alternative but don't have enough details to move forward.
#4
I worry that some parts have to be moved to do that. The other problem (much bigger) would be programming the ECU for the larger tank. But I hope that someone will do that and post detailed instructions :-)
#5
It looks like The Long Ranger makes a 70 L sub-tank designed for 200 series vehicles that can be installed without the rest of the world standard sub-tank already in place. They are distributed via ARB and I plan to contact them to determine availability. http://thelongranger.com.au/toyota/l...-series/ta65sp The downside to this solution is that it is a secondary transfer tank. When the standard tank is low, hit the lift pump and the sub-tank contents will be transferred to the main tank.
The factory fuel tank with standard sub-tank items could likely be purchased. However the original factory tank would require a return line installed. This can be done but it is dangerous and requires the original tank to be removed, gas and fumes removed. I understand the parts are expensive.
From my research, either sub-tank can be added without relocating any factory items. There is enough room above the spare wheel to fit either tank. I will continue to investigate as the limited range of the standard vehicle is it's major downfall.
The factory fuel tank with standard sub-tank items could likely be purchased. However the original factory tank would require a return line installed. This can be done but it is dangerous and requires the original tank to be removed, gas and fumes removed. I understand the parts are expensive.
From my research, either sub-tank can be added without relocating any factory items. There is enough room above the spare wheel to fit either tank. I will continue to investigate as the limited range of the standard vehicle is it's major downfall.
The following users liked this post:
ClaytonW (03-26-17)
#6
Pole Position
It looks like The Long Ranger makes a 70 L sub-tank designed for 200 series vehicles that can be installed without the rest of the world standard sub-tank already in place. They are distributed via ARB and I plan to contact them to determine availability. http://thelongranger.com.au/toyota/l...-series/ta65sp The downside to this solution is that it is a secondary transfer tank. When the standard tank is low, hit the lift pump and the sub-tank contents will be transferred to the main tank.
The factory fuel tank with standard sub-tank items could likely be purchased. However the original factory tank would require a return line installed. This can be done but it is dangerous and requires the original tank to be removed, gas and fumes removed. I understand the parts are expensive.
From my research, either sub-tank can be added without relocating any factory items. There is enough room above the spare wheel to fit either tank. I will continue to investigate as the limited range of the standard vehicle is it's major downfall.
The factory fuel tank with standard sub-tank items could likely be purchased. However the original factory tank would require a return line installed. This can be done but it is dangerous and requires the original tank to be removed, gas and fumes removed. I understand the parts are expensive.
From my research, either sub-tank can be added without relocating any factory items. There is enough room above the spare wheel to fit either tank. I will continue to investigate as the limited range of the standard vehicle is it's major downfall.
If you're planning, the thread needs reading for certain. Maybe over 2-3 days. It's definitely not cheap, v. carrying a couple of jerry cans on either a bumper mount or roof rack. So far, our trips away from gas haven't been more than 200 miles or so. Something to think about if you're planning 2 weeks in the boonies.
#7
That was an interesting read. It looks like charcoal canister relocate or delete. Sounds like quite a few hours of work. I recently did a charcoal relocate on my Lotus Elise as part of a complete mechanical re-build, if I can find space in that car the LX should be far more straightforward, with better access. I have contacted The Long Ranger about fitting their 70 L auxiliary tank into an LX and await their feedback. Your point about price is valid, I don't mind putting in the labor but $1,500 USD on a fuel tank is a bit of a tough pill to swallow. Considering this model and variants have been around for basically 10 years, I'm surprised there are not more readily available solutions?
Trending Topics
#8
Pole Position
That was an interesting read. It looks like charcoal canister relocate or delete. Sounds like quite a few hours of work. I recently did a charcoal relocate on my Lotus Elise as part of a complete mechanical re-build, if I can find space in that car the LX should be far more straightforward, with better access. I have contacted The Long Ranger about fitting their 70 L auxiliary tank into an LX and await their feedback. Your point about price is valid, I don't mind putting in the labor but $1,500 USD on a fuel tank is a bit of a tough pill to swallow. Considering this model and variants have been around for basically 10 years, I'm surprised there are not more readily available solutions?
The 200 series may have been around since 2008, but that said, total quantities are no where near those of, say, a 4Runner. E.g., in 2015, Toyota exported ~7000 total (3000 Land Cruisers and 4000 LX's into all of north America. They exported 79,000 4Runners.
If I had fabrication facilities, I'd envision a tank to fit the spare tire cavity or above it. I'd use tank ends...what you see at each end of a large propane tank...about 30" in diameter, and add some steel strip between the 2 ends to fit the space. I doubt it would run $1500.
Will a charcoal canister "delete" in TX screw up your next smog check? When I lived there, the only smog test was to clip a piece of chemically treated paper to the end of the exhaust to make sure you weren't using leaded gas.
Steve...ex-TX
The following users liked this post:
ggebhardt (04-02-17)
#9
While I haven't opened everything up to look yet, there are typically two purge valves in the charcoal canister system. If the canister were removed, you would plug the valves back in so that the ECU did not recognize a problem and cause a MIL. Without coming up with a solution like this, there would definitely be an issue passing smog inspection.
#10
Pole Position
While I haven't opened everything up to look yet, there are typically two purge valves in the charcoal canister system. If the canister were removed, you would plug the valves back in so that the ECU did not recognize a problem and cause a MIL. Without coming up with a solution like this, there would definitely be an issue passing smog inspection.
#11
I have noticed that the low fuel light does not come on until the computer says I am down to 8 miles of range. The needle is just barely above the last tick mark. Is this normal?
#12
Pole Position
for me and the LX units I have owned, when the red light comes on you still got 4 gallons of fuel left. I can get about 20 gallons in the tank when it says empty.
#13
I did hear back from the Long Ranger shop in Australia. They did not have any experience installing a secondary tank in a LX and did not seem motivated to provide any further assistance. Long Ranger was concerned there may be some AHC related hardware above the factory tank that could interfere.
After research the best alternative seems to be the 15 gallon aux tank from Tembo. The thread on the install at IH8mud seems successful and cost of parts shipped to USA should be less than $1,500. Based on the price, the amount of labor involved and my concern about cleaning the factory tank sufficiently to avoid any problem while drilling the connection hole, I'm skipping this idea. If anyone does install a tank, I would be grateful to read about your installation experience. A LX with a 40 gallon tank would be just about the perfect vehicle!
After research the best alternative seems to be the 15 gallon aux tank from Tembo. The thread on the install at IH8mud seems successful and cost of parts shipped to USA should be less than $1,500. Based on the price, the amount of labor involved and my concern about cleaning the factory tank sufficiently to avoid any problem while drilling the connection hole, I'm skipping this idea. If anyone does install a tank, I would be grateful to read about your installation experience. A LX with a 40 gallon tank would be just about the perfect vehicle!
#14
Pole Position
I did hear back from the Long Ranger shop in Australia. They did not have any experience installing a secondary tank in a LX and did not seem motivated to provide any further assistance. Long Ranger was concerned there may be some AHC related hardware above the factory tank that could interfere.
After research the best alternative seems to be the 15 gallon aux tank from Tembo. The thread on the install at IH8mud seems successful and cost of parts shipped to USA should be less than $1,500. Based on the price, the amount of labor involved and my concern about cleaning the factory tank sufficiently to avoid any problem while drilling the connection hole, I'm skipping this idea. If anyone does install a tank, I would be grateful to read about your installation experience. A LX with a 40 gallon tank would be just about the perfect vehicle!
After research the best alternative seems to be the 15 gallon aux tank from Tembo. The thread on the install at IH8mud seems successful and cost of parts shipped to USA should be less than $1,500. Based on the price, the amount of labor involved and my concern about cleaning the factory tank sufficiently to avoid any problem while drilling the connection hole, I'm skipping this idea. If anyone does install a tank, I would be grateful to read about your installation experience. A LX with a 40 gallon tank would be just about the perfect vehicle!
I'm still looking at the option of a rear bumper and a couple of NATO jerry cans...thinking I can get most of a decent rear bumper for $1500, diy the installation and that should be it.
The following users liked this post:
zink (08-06-17)
Thread
Thread Starter
Forum
Replies
Last Post
qewani1
LS - 1st and 2nd Gen (1990-2000)
2
04-14-09 03:09 PM